After rain or inclement weather hit the area, water would pool along the patio area where it was sinking.
Because the concrete patio was only sinking along one side (towards the home), water would pool up right near the entry door.
Due to the large size of the patio, penny-sized installation ports were drilled every four feet ensuring the slab would lift accurately.
As the slab was raised back to the appropriate level, each installation hole is then grouted over making the PolyRenewal System discreet.
The patio entrance to this West Jefferson, NC home had sank over the last two years. The homeowners had grown accustomed to the unlevel concrete and didn’t have a need to fix the problem. Unfortunately, water began pooling along the area affected the most by the settlement. This area was just outside the door, causing the homeowners to step in a puddle when entering or leaving the home after rainstorms. After months of dealing with the problem, they researched a company that would provide them with an alternative solution to tearing out their entire patio. Tar Heel Basement Systems became their concrete repair contractor.
System Design Specialist, Mike Jones, designed a solution that would meet the wants of the homeowners and needs of the home. The patio would not need to be torn out and replaced. Fortunately, the PolyRenewal System would raise the sinking concrete slab, preventing the problem from recurring again with minimal disruption to the slab itself.
Because the patio was rather large, 29 feet by 11 feet, penny-sized installation holes were strategically drilled every four feet in the slab. Unlike, Mud jacking that requires two-inch holes every two feet, PolyRenewal is much more discreet. Installation injection ports were placed in each hole, where the structural grade polymer was released. The expanding properties of the polyurethane allowed for the team to achieve stability and accurately lift the sinking slab back to proper level using only 205 pounds of foam. The penny-sized holes were grouted over, make the system almost invisible. The waterproof foam will remain underneath the slab and intact for many years to come.
The PolyRenewal System was installed in a matter of hours, allowing the homeowners to walk along their patio just 15 minutes after the slab was raised. The homeowners are happy to have their patio restored efficiently and within their budget!
Installing Contractor: Tar Heel Basement Systems
System Design Specialist: Mike Jones
Products Used: 205 Pounds of Low Density Polyurethane Foam (PL250)